features: compact 400w with 1u height power density: 11.11 watts/cu in 220w ~ 400w ac - dc active pfc switching power supply prl0602dn dual output series input voltage: 90 ~ 264vac full range, 47 ~ 63hz. input current: 8a at 90vac. inrush current: max. 70a@230vac & 35a@115vac; both under cold start conditions. power factor correction: >0.9 @ vin: 230vac full load. transient response: returns to within 1% in less than 2.5ms for a 50% load change and the peak transient does not excess 5%. overshoot: turn - on & off overshoot < 5% over nominal voltage. efficiency: 75% minimum (measuring at 230v and full load). turn on delay : 1.5 second maximum at 120 vac. hold up time: 16 msec minimum at 120 vac and 75% of rated maximum load. adjustability : output user adjustable +/ - 5% minimum. fan drive: 12vdc/300ma offering to drive an external fan. fan fail (ff) alarm: designated as ff on pin 3 of cn1 to monitor the status of fan. this signal is an open collector output rated for 15vdc/5ma sink current maximum, it will go high when a fan failure is detected. remote on - off: designated as inh on pin4 of cn1, requires a low signal to inhibit output. power supply on: green led designated as led1 on the pcb. power good: designated as pg on cn1 and ttl high 100 - 500ms after dc regulation. it goes low at least 1ms before loss of regulation. input fusing protection: one t8a/250v fuse inserted in primary. over - power protection: 110~140% of i - max; auto - recovery. short circuit protection: trip without damage and auto - recovery. over voltage protection: unit latching down when output exceed 130% and recycle ac input to reset. over - temperature protection: unit protected of excessive operating ambient 110 5 , and automatic recovery. operating temperature: 0 to 70 ambient, de - rating at 2.5% per degree from 50 to 70 . switching frequency: pfc 68 khz, pwm 55 khz for d1224 & 50 khz for other models. storage temperature : - 20 to 85 . operating humidity : 5% to 90% rh, non - condensing. storage humidity: 5% to 95% rh, non - condensing. emc: en55022 class b conducted / radiated, en61000 - 3 - 2, en61000 - 3 - 3; en55024 (iec61000 - 4 - 2, iec61000 - 4 - 3, iec61000 - 4 - 4, iec61000 - 4 - 5, iec61000 - 4 - 6, iec61000 - 4 - 11). vibration: 5 ~ 50 hz, acceleration 7.35 m/s*s on x,y and z axis. safety regulation: ul60950 - 1, csa c22.2 no. 60950 - 1 and cb certificate. leakage current: < 3.5ma @ 264vac. (optional for 500ua max. at 240vac / 300ua max. at 120vac input) hi - pot test : 1500 vac input line to chassis (10ma dc cut off current); isolating 3000vac primary to secondary windings; primary to core 1500vac. all for 3 sec. grounding test: apply 25 a from ground pin of the three prong plug to the far most earth. max allowable resistance 0.1 ohm. warranty: 2 years. mtbf: 100000 hrs (according to mil - hbk - 217f) at 30 . cooling: internal fan is provided. burn in: 45 +/ - 5 degree c for 1 hour @230vac with full load. enclosure : u type: 6(l) x 4(w) x 1.5(h) inches. u type with top cover option: 6(l) x 4(w) x 1.57(h) inches. e type: 7(l) x 4(w) x 1.6(h) inches. f type: 6(l) x 4(w) x 2(h)inches. weight : maximum weight is 800g. copy right ultra level tech co., ltd 2014, all right reserved. specifications subject to change without notice. product specifications: u type: 6(l) x 4(w) x 1.5(h) e type: 7(l) x 4(w) x 1.6(h) f type: 6(l) x 4(w) x 2(h) c type : 6(l) x 4(w) x 1.57(h) cb ultra level tech co., ltd. we supply the power customers need iso9001 www.ultralevel.com.tw tel:+886 - 2 - 29180118 fax:+886 - 2 - 29181465
output voltage / current rating chart: measured at output power connector. note: * prl0602dn series are designated as prl0602dnx - y where x can be u (u - chassis), c (u - chassis with top vented cover), e (enclosed type with side built - in fan) or f (enclosed type with top built - in fan); y can be 0512, 0524, 0548, 1224. ? for models u chassis type which need external forced airflow min. 26.84 cfm to achieve maximum power. ? type u, e & f with forced air cooling: total combined power of v1 and v2 not to exceed 400w for prl0602dnx - 1224 and 320w for oth er models. ? type u & c with convection cooling: total combined power of v1 and v2 not to exceed 200w for rl0602dnx - 1224 and 180w for other models. * ripple and noise is measured from 10khz to 20mhz bandwidth at output with parallel 0.1f ceramic and 22f electrolytic capa cit ors. * 10% minimum load is required to maintain the ripple and regulation. * output is fully isolated. input and output connector (cn2): terminal block: howder part no. hd - 121 - 7p or molex: mating jst vh series. pcb labeling: l = line; n = neutral; g = chassis ground. output pin assignment: (see table in right). mounting inserts: 6 places m4x0.7. maximum penetration 2mm sees outline drawing for location. logic signal connector (cn1) : mating: jst xhp - 4 or equivalent (chyao shiunn js - 2001 - 04); mating pins: jst sxh - 002t - p0.6 for awg 30 to 26. fan driver connector (fan2) : 12vdc/300ma is available to drive an external fan. mating: jst xhp - 2 (2 pins 0.98 pitch) or equivalent (chyao shiunn js - 2001 - 02). howder molex pin 1: v1 pins 1 ~ 3: v1 pin 2 ~ 3: rtn pins 4 ~ 8: rtn pin 4: v2 pins 9 ~ 10: v2 pin 5: gnd pin 12: gnd pin 6: neutral pin 14: neutral pin 7: line pin 16: line copy right ultra level tech co., ltd 2014, all right reserved. specifications subject to change without notice. outline drawing: model number output voltage max. output current regulation ripple & noise type u & e & f (force air) type u, c (convection) prl0602dnx - 0512 v1:+5v 30a 15a +/ - 5% 1% v2:+12v 20.83a 13.33a +/ - 5% 1% prl0602dnx - 0524 v1:+5v 30a 15a +/ - 5% 1% v2:+24v 10.42a 6.67a +/ - 5% 1% prl0602dnx - 0548 v1:+5v 30a 15a +/ - 5% 1% v2:+48v 5.21a 3.33a +/ - 5% 1% prl0602dnx - 1224 v1:+12v 20.83a 12.5a +/ - 5% 1% v2:+24v 10.42a 8.33a +/ - 5% 1% ultra level tech co., ltd. we supply the power customers need iso9001 www.ultralevel.com.tw tel:+886 - 2 - 29180118 fax:+886 - 2 - 29181465
copy right ultra level tech co., ltd 2014, all right reserved. specifications subject to change without notice. prl0602dnc series (u chassis with top vented cover : 6 (l) x 4(w) x 1.57(h) inches; weight: 650g. ultra level tech co., ltd. we supply the power customers need iso9001 www.ultralevel.com.tw tel:+886 - 2 - 29180118 fax:+886 - 2 - 29181465 prl0602dnu series (u - chassis type): 6 (l) x 4(w) x 1.5(h) inches; weight: 600g.
ultra level tech co., ltd. we supply the power customers need iso9001 prl0602dn f series (enclosed with top built - in fan type): 6 (l) x 4(w) x 2(h) inches; weight: 800g. prl0602dne series (enclosed with side built - in fan type): 7 (l) x 4(w) x 1.6(h) inches; weight: 750g. copy right ultra level tech co., ltd 2014, all right reserved. specifications subject to change without notice. www.ultralevel.com.tw tel:+886 - 2 - 29180118 fax:+886 - 2 - 29181465
|
