TFS125D.doc v e rsion 2.0 21.02.2002 vi telefilter filter specification tfs 125 d 1/5 ______________________________________________________________________________________________________ vi telefilter vectron international, inc. potsdamer stra?e 18 267 low ell road d 14 513 teltow / germany hudson, nh 03051 / usa measurement condition ambient temperature: 23 c input pow e r level: 0 dbm source impedance: 50 ? single ended load impedance: 50 ? single ended terminating impedances: *) input: 175 ? || -22.5 pf output: 200 ? || -22.7 pf ch aracteristics remark: the reference lev e l for the relativ e attenuation a rel of tfs 125d is the minimu m of the pass band attenuation a min . this v a lue is defined as the insertion loss a e . the centre frequency f c is the arithmetic mean v a lue of the upper and low e r frequencies at the 3 db filter attenuation lev e l relativ e to the insertion loss a e . the nominal frequency f n is fix ed on 125,0 m h z w i thout tolerance. the giv en v a lues for the relativ e attenuation a rel and for the group delay ripple hav e to be reached at t he frequencies giv en below ev en if the centre frequency f o is shifted due to the temperature coefficient of frequency tc f in the operating temperature range and due to a production tolerance for the centre frequency f o . d a t a ty p. value limit insertion loss a e = a min - max. 8 db (reference level) nominal frequency f n - 125,0 mhz 3 db - bandw idth bw min. 400 khz pass band ripple - max. 1,0 db relativ e a ttenuation a rel f n 1,8 mhz ... f n 6 mhz - min. 20 db f n 6 mhz ... f n 39 mhz - min. 35 db f n - 124 mhz ... f n - 39 mhz - min. 20 db f n + 39 mhz ... f n + 775 mhz - min. 20 db group delay f n - m a x . 1 s group delay ripple f n ? 80 khz ... f n + 80 khz - max. 1 s input pow er lev e l - max. + 10 dbm operating temperature range - 5 c ... + 75 c storage temperature range - 40 c ... + 85 c *) the terminating impedances depend on parasitics and q-v a lues of matching elem ents and the board used, and are to be understood as reference v a lues only . should there be additional questions, do not hesitate to ask fo r an application not e or contact our design team. g e n e r a t e d : checked / approv ed: tel: (+49) 3328 4784-52 / fax: (+49) 3328 4784-30 tel: (603) 598-0070 fax: (603) 598-0075 e-mail: tft@telefilter.co m e-mail: v ti@v tin h . co m vi telefilter reserves the right to m a ke ch anges to the product(s) and/or inform ation contained herein without notice. no liab ility is assum e d as a result of their use or application. no rights unde r any patent accom p any the sale of any such product(s) or infor m a tion. www..net
TFS125D.doc v e rsion 2.0 21.02.2002 vi telefilter filter specification tfs 125 d 2/5 ______________________________________________________________________________________________________ vi telefilter vectron international, inc. potsdamer stra?e 18 267 low ell road d 14 513 teltow / germany hudson, nh 03051 / usa cons truc tion a nd pin c onfigura t ion 1 output 2 ground 3 ground 4 ground 5 ground 6 input 7 ground 8 ground 9 ground 10 ground datecode: year+week m 2000 n 2001 p 2002 ... t f s 12 5d p0 8 1 2 3 4 6 5 7 8 9 10 d a t e c ode 50 ? sin g l e en d e d test circu i t l2 output 50 ohm c2 input 50 ohm c1 l1 saw 2,3,4,5,7 1 6 8,9,10 tel: (+49) 3328 4784-52 / fax: (+49) 3328 4784-30 tel: (603) 598-0070 fax: (603) 598-0075 e-mail: tft@telefilter.co m e-mail: v ti@v tin h . co m vi telefilter reserves the right to m a ke ch anges to the product(s) and/or inform ation contained herein without notice. no liab ility is assum e d as a result of their use or application. no rights unde r any patent accom p any the sale of any such product(s) or infor m a tion.
TFS125D.doc v e rsion 2.0 21.02.2002 vi telefilter filter specification tfs 125 d 3/5 ______________________________________________________________________________________________________ vi telefilter vectron international, inc. potsdamer stra?e 18 267 low ell road d 14 513 teltow / germany hudson, nh 03051 / usa stability characteristics after the follow i ng tests the filter shall meet the w hole specification: 1. shock: 500g, 18 ms, half sine w a ve, 3 shocks each plane; din iec 68 t2 - 27 2. vibration: 10 hz to 500 hz, 0,35 mm or 5g respective ly , 1 octave per min, 10 cy cles per plan, 3 plans; din iec 68 t2 - 6 3. change of temperature: -55 c to 125c / 30 min. each / 10 cy cles din iec 68 part 2 ? 14 test n 4. resistance to solder heat (reflow ): reflow possible: tw ice max.; for temperature conditions, pleas e refer to the attached "air re flow temperature conditions" on page 4; packin g tape & reel: iec 286 - 3, w i th exception of value for n and minimum bending radius; tape ty pe ii , embossed carrier tape w i th top cover tape on the upper side; max. pieces of filters per reel: 2000 reel of empty components at start: min 300 mm reel of empty components at start including leader: min 500 mm trailer min 300 mm d o p o e f w p 1 e m bo ss ed c a r r i e r t ape co v e r t a p e g p 2 b o a o d 1 t a p e ( a ll d i m e n s io n s in m m ) w : 1 6 0 , 3 p o : 4 0 , 1 d o : 1 , 5 + 0 , 1 e : 1 , 7 5 0 , 1 f : 7 , 5 0 , 1 g ( m i n ) : 0 , 6 0 p 2 : 2 0 , 1 p 1 : 1 2 0 , 1 d 1 ( m i n ) : 1 , 5 a o : 7 , 6 0 0 , 1 b o : 9 , 6 0 0 , 1 ct c t : 1 3 , 5 0 , 1 a c n w 1 w 2 r e e l ( a l l d i m e n s io n s i n m m ) : a : 3 3 0 w 1 : 1 6 , 4 0 + 2 , 0 w 2 (m a x ) : 2 2 , 4 n (m i n ) : 6 0 c : 1 2 , 8 + 0 , 1 / -0 . 1 the minimum bending radius is 45 mm. the mounting surface of the filters faces the bottom side of the embossed carrier tape. markings on the filters can be read if the upper side of the carrier tape is regarded w i th the sprocket holes on its right. tel: (+49) 3328 4784-52 / fax: (+49) 3328 4784-30 tel: (603) 598-0070 fax: (603) 598-0075 e-mail: tft@telefilter.co m e-mail: v ti@v tin h . co m vi telefilter reserves the right to m a ke ch anges to the product(s) and/or inform ation contained herein without notice. no liab ility is assum e d as a result of their use or application. no rights unde r any patent accom p any the sale of any such product(s) or infor m a tion.
TFS125D.doc v e rsion 2.0 21.02.2002 vi telefilter filter specification tfs 125 d 4/5 ______________________________________________________________________________________________________ vi telefilter vectron international, inc. potsdamer stra?e 18 267 low ell road d 14 513 telto w / g e rmany hudson, nh 03051 / usa a i r re flow te mpe r a t ure c onditions 1st and 2nd air reflow profile n a m e : pre-heating periods main-heat ing periods peak temperature t e mp eratu r e: 150 c - 170 c over 200 c 255 c 5 c t i m e : 60 sec. - 90 sec. 20 sec. - 25 sec. c h i p - m ount a i r re f l ow pr of i l e ti m e / s e c . t e mper at ur e / c 0 20 40 60 80 100 120 140 160 180 200 220 240 260 0 2 0 4 0 6 0 8 0 100 120 140 160 180 200 220 240 t able for temperature vs. time during the air reflow process t o lerance of temperatures: 5 c time / sec. temperature / c time / sec. temperature / c 0 23 140 160 10 34 150 161 20 46 160 164 30 60 170 170 40 80 180 180 50 103 190 205 60 121 195 230 70 134 200 255 80 143 205 230 90 150 210 205 100 154 215 180 110 156 220 165 120 158 230 140 130 159 240 120 tel: (+49) 3328 4784-52 / fax: (+49) 3328 4784-30 tel: (603) 598-0070 fax: (603) 598-0075 e-mail: tft@telefilter.co m e-mail: v ti@v tin h . co m vi telefilter reserves the right to m a ke ch anges to the product(s) and/or inform ation contained herein without notice. no liab ility is assum e d as a result of their use or application. no rights unde r any patent accom p any the sale of any such product(s) or infor m a tion.
TFS125D.doc v e rsion 2.0 21.02.2002 vi telefilter filter specification tfs 125 d 5/5 ______________________________________________________________________________________________________ vi telefilter vectron international, inc. potsdamer stra?e 18 267 low ell road d 14 513 telto w / g e rmany hudson, nh 03051 / usa history version reason of changes name date dev e lopment specification 1.0 - generation of development specification steiner 17.04.1999 filter specification 2.0 - terminating impedances added steiner 21.02.2002 - temperature range corrected tel: (+49) 3328 4784-52 / fax: (+49) 3328 4784-30 tel: (603) 598-0070 fax: (603) 598-0075 e-mail: tft@telefilter.co m e-mail: v ti@v tin h . co m vi telefilter reserves the right to m a ke ch anges to the product(s) and/or inform ation contained herein without notice. no liab ility is assum e d as a result of their use or application. no rights unde r any patent accom p any the sale of any such product(s) or infor m a tion.
|
