filename: tfs 433s.doc version 1.5 14.07.2004 vi telefilter filter specification tfs 433s 1/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. measurement condition ambient temperature: 23 c input power level: 0 dbm terminating impedance: input: 50 ? output: 50 ? characteristics remark: the reference level for the relative attenuation a rel of tfs 433s is the minimum of the pass band attenuation a min . this value is defi ned as the insertion loss a e . the centre frequency f c is the arithmetic mean value of the upper and lower frequencies at the 3 db filt er attenuation level relative to the insertion loss a e . the given values for the relative attenuation a rel and the group delay ripple have to be reached at the frequencies given below, even if the centre frequency f c is shifted due to the temperature coefficient of frequency tc f in the operating temperature range and due to a production tolerance for the centre frequency f c . d a t a typ. value tolerance / limit insertion loss a e 3,1 db 3,8 db (reference level) - - nominal frequency f n - 433,92 mhz centre frequency f c 433,92 mhz - passband pb 1 db 5 mhz min. 1,71 mhz relative attenuation a rel f n - 0,92 mhz ... f n + 0,79 mhz 0,45 db max. 1 db f n - 8,42 mhz ? f n - 18,92 mhz 50 db min. 37 db f n - 18,92 mhz ? f n - 25,92 mhz 60 db min. 52 db f n - 25,92 mhz ? f n - 40,92 mhz 65 db min. 42 db f n - 40,92 mhz ? f n - 83,92 mhz 70 db min. 52 db f n - 83,92 mhz ? f n - 423,92 mhz 68 db min. 37 db f n + 9,58 mhz ? f n + 20,08 mhz 25 db min. 12 db f n + 20,08 mhz ? f n + 41,08 mhz 50 db min. 34 db f n + 41,08 mhz ? f n + 141,08 mhz 65 db min. 50 db f n + 141,08 mhz ? f n + 566,08 mhz 45 db min. 40 db operating temperature range otr - - 40 c ... + 85 c storage temperature range - - 45 c ... + 90 c temperature coefficient of frequency tc f * -35 ppm/k - input power level - max. 10 dbm *) ? f(hz) = tc f (ppm/k) x (t-t 0 ) x f to (mhz). generated: checked / approved:
filename: tfs 433s.doc version 1.5 14.07.2004 vi telefilter filter specification tfs 433s 2/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. filter characteristic construction and pin connection (all dimensions in mm) sq 3 , 8 1 -0,10 +0,20 1 3 7 5 1,2 max. 0,6 1,78 0,1 1,78 2,54 1 2 0 13 5 7 date code 50 ohm test circuit 433s s29 1 output rf return 2 output 3 ground 4 ground 5 input rf return 6 input 7 ground 8 ground date code: year + week s 2004 t 2005 u 2006 ... 100 200 300 400 500 600 700 800 900 1000 -100 -90 -80 -70 -60 -50 -40 -30 -20 -10 0 frequency in mhz magnitude in db 400 410 420 430 440 450 460 470 480 -100 -90 -80 -70 -60 -50 -40 -30 -20 -10 0 frequency in mhz magnitude in db l1 l2 6 2 3, 4, 7, 8 1 5
filename: tfs 433s.doc version 1.5 14.07.2004 vi telefilter filter specification tfs 433s 3/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. stability characteristics after the following tests the filter shall meet the whole specification: 1. shock: 500g, 18 ms, half sine wave, 3 shocks each plane; din iec 68 t2 - 27 2. vibration: 10 hz to 500 hz, 0,35 mm or 5 g respecti vely, 1 octave per min, 10 cycles per plan, 3 plans; din iec 68 t2 - 6 3. change of temperature: -55 c to 125c / 30 min. each / 10 cycles din iec 68 part 2 ? 14 test n 4. resistance to solder heat (reflow): reflow possible: twice max.; for temperature conditions refer to the attac hed "air reflow temperature conditions" on page 4; packing tape & reel: iec 286 ? 3, with exeption of value for n and minimum bending radius; tape type ii, embossed carrier tape with top cover tape on the upper side; max. pieces of filters peer reel: 3000 reel of empty components at start: min. 300 mm reel of empty components at start including leader: min. 500 mm trailer: min. 300 mm g do w ct f e g d1 p2 p1 po bo ao pull off direc tion pin m a rke r t yp da te co d e ko t a c n w 1 w 2 the minimum bending radius is 45 mm. tape (all dimensions in mm) w : 12,00 0,3 po : 4,00 0,1 do : 1,50 +0,1/-0 e : 1,75 0,1 f : 5,50 0,05 g(min) : 0,75 p2 : 2,00 0,05 p1 : 8,00 0,1 d1(min) : 1,50 a o : 4,30 0,1 bo : 4,30 0,1 ct : 9,5 0,1 reel (all dimensions in mm) a : 330 w1 : 12,4 +2/-0 w2(max) : 18,4 n(min) : 50 c : 13,0 +0,5/-0,2
filename: tfs 433s.doc version 1.5 14.07.2004 vi telefilter filter specification tfs 433s 4/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. air reflow temperature conditions 1st and 2nd air reflow profile name: pre-heating periods main-heating periods peak temperature temperature: 150 c - 170 c over 200 c 255 c 5 c time: 60 sec. - 90 sec. 20 sec. - 25 sec. chip-mount air reflow profile time / sec. temperature / c 0 20 40 60 80 100 120 140 160 180 200 220 240 260 0 20 40 60 80 100 120 140 160 180 200 220 240 table for temperature vs. time during the air reflow process tolerance of temperatures: 5 c time / sec. temperature / c time / sec. temperature / c 0 23 140 160 10 34 150 161 20 46 160 164 30 60 170 170 40 80 180 180 50 103 190 205 60 121 195 230 70 134 200 255 80 143 205 230 90 150 210 205 100 154 215 180 110 156 220 165 120 158 230 140 130 159 240 120
filename: tfs 433s.doc version 1.5 14.07.2004 vi telefilter filter specification tfs 433s 5/5 tele filter gmbh potsdamer stra?e 18 d 14 513 teltow / germany tel: (+49) 3328 4784-0 / fax: (+49) 3328 4784-30 e-mail: tft@telefilter.com vi telefilter reserves the right to make changes to the produc t(s) and/or information contained herein without notice. no liab ility is assumed as a result of their use or application. no rights under any patent accompany the sale of any such product(s) or infor mation. history version reason of changes name date 1.0 - generation of development specification acco rding to customer specification. dr. sabah 17.06.2003 1.1 - filter specification, add oft typical values dr. sabah 19.08.2003 1.2 - change relative attenuation - f n + 156,08 mhz ? f n +566,08 mhz typ. 50db min. 45db change to - f n + 141,08 mhz ? f n +566,08 mhz typ. 45db min. 35db m. springfeldt 12.02.2004 1.3 - remove mistake in relative attanuation m. springfeldt 13.02.2003 1.4 - change relative attenuation - f n + 156,08 mhz ? f n +566,08 mhz typ. 50db min. 45db change to - f n + 141,08 mhz ? f n +566,08 mhz typ. 45db min. 40db m. springfeldt 26.02.2004 1.5 - change temperature coefficient of frequency - change packing m. springfeldt 14.07.2004
|
